CALL US

+86 15517153367

use of quarry fine as partial replacement of concrete as a

use of quarry fine as partial replacement of concrete as a

Use of Quarry Fine as Partial Replacement of Concrete as

2014-10-10  Use of Quarry Fine as Partial Replacement of Concrete as a Replacement of Fine Aggregate in Concrete (Evaluation of Workability and Compressive Strength) Vivek Singh Rajput1 Summit Pandey2 Devansh Jain3 A.K. Saxena4 1,2M.E Scholar 3Assistant Professor 4Associate Professor 1,2,3,4Department of Civil Engineering 1,2,3,4 Laxmi Narian College of ...

get price

Use of Quarry Fine as Partial Replacement of Concrete as a ...

IJSRD - International Journal for Scientific Research Development Vol. 2, Issue 07, 2014 ISSN (online): 2321-0613 Use of Quarry Fine as Partial Replacement of Concrete as a Replacement of Fine Aggregate in Concrete (Evaluation of Workability and Compressive Strength) Vivek Singh Rajput1 Summit Pandey2 Devansh Jain3 A.K. Saxena4 1,2 M.E

get price

Studies on Quarry Dust as Partial Replacement of Fine ...

2017-4-30  to use Quarry dust to replace the fine aggregates in concrete. Following are some of the conclusions drawn from the results of this investigation: 1. Quarry dust can be used as a finer material which can reduce the voids in concrete. 2. Up to 20% replacement of fine aggregates by quarry dust, the results obtained are satisfactory. 3.

get price

Study of Concrete Involving Use of Quarry dust as Partial ...

2015-3-9  facing. In this paper, the issues of environmental and economic concern are addressed by the use of quarry dust as partial replacement of fine aggregates in concrete. Fine aggregates were replaced by quarry dust as 0%, 10%, 20%, 30% and 40% by weight for M-25 mix. The concrete specimens were tested for compressive strength,

get price

Use of Quarry Dust as fine aggregates by Partial ...

2017-7-15  1. Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete. 2. The concept of replacement of natural fine aggregate (sand) by quarry dust may help in many ways such as it is helpful to control environment pollution, erosion of river bank might stop and also the waste quarry material can be

get price

(PDF) EFFECT OF QUARRY DUST AS PARTIAL

Hence the use of Bamboo and quarry dust as replacement for coarse aggregate and fine aggregate in concrete is reducing the Environmental wastes which

get price

Suitability of Quarry Dust as a Partial Replacement of ...

To overcome this problem, present study is focused on the suitability to utilize the quarry dust in Self Compacting Concrete (SCC) partially as fine aggregate with the natural fine aggregates. In this work, quarry dust is used as replacement of sand in a different level (0%, 15%, 30%, 45% and 60%) for producing the SCC.

get price

Quarry Mud as Partial Replacement for Fine Combination ...

Concrete Cube Made by Using Quarry Dust. The concrete cubes are prepared by using replacement of 10%, 20%, and 30% of quarry dust. These cubes are tested for compressive strength at 3, 7 and 14 days. Three cube specimens were tested at 3, 7, and 14 days in each percentage and obtained the compressive strength. 6.

get price

Sustainable use of industrial-waste as partial replacement ...

2016-12-1  Sustainable use of industrial-waste as partial replacement of fine aggregate for preparation of concrete – A review. ... Basar and Aksoy (2012) have stated that waste foundry sand can be successfully used in making great quality ready-mix concrete as partial supplanting of fine aggregate with no unfavorable mechanical, micro-structural and ...

get price

Studies on Quarry Dust as Partial Replacement of Fine ...

2017-4-30  to use Quarry dust to replace the fine aggregates in concrete. Following are some of the conclusions drawn from the results of this investigation: 1. Quarry dust can be used as a finer material which can reduce the voids in concrete. 2. Up to 20% replacement of fine aggregates by quarry dust, the results obtained are satisfactory. 3.

get price

AN EXPERIMENTAL STUDY ON USE OF QUARRY DUST

2021-5-4  AN EXPERIMENTAL STUDY ON USE OF QUARRY DUST AND RECYCLED AGGREGATE AS PARTIAL REPLACEMENT OF FINE AND COARSE AGGREGATE IN CEMENT CONCRETE Sonam Verma1, Mr. Rakesh Kumar Pandey2, Mr. Abhishek Singh3 1Student, M. Tech (Structural Engineering), Amity University Raipur Chhattisgarh 2HOD,

get price

Use of Quarry Dust as fine aggregates by Partial ...

2017-7-15  1. Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete. 2. The concept of replacement of natural fine aggregate (sand) by quarry dust may help in many ways such as it is helpful to control environment pollution, erosion of river bank might stop and also the waste quarry material can be

get price

Suitability of Quarry Dust as a Partial Replacement of ...

To overcome this problem, present study is focused on the suitability to utilize the quarry dust in Self Compacting Concrete (SCC) partially as fine aggregate with the natural fine aggregates. In this work, quarry dust is used as replacement of sand in a different level (0%, 15%, 30%, 45% and 60%) for producing the SCC.

get price

Effect of Marble Powder and Quarry Dust as Partial ...

2019-11-22  Effect of Marble Powder and Quarry Dust as Partial Replacement for Fine Aggregate on Concrete - written by Dr. M. Kannan, Sandhya, Swarnalakshmi published on 2019/11/22 download full article with reference data and citations

get price

PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

2019-4-21  concrete cubes of size 150mm×150mm×150mm were cast for finding its compressive strength. From the experimental studies it is observed that by 25% of partial replacement of cement with quarry dust improved hardened concrete properties. Keywords: Quarry dust, cement, water, aggregates. -----***-----1. INTRODUCTION Quarry dust is a waste product ...

get price

Optimum utilization of Quarry dust as partial replacement ...

River sand is most commonly used fine aggregate in concrete but due to acute shortage in many areas, availability, cost environmental impact are the major concern (Ahmed et.al., 1989). To overcome from this crisis, partial replacement of sand

get price

EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

2018-11-5  EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL REPLACEMENT OF CEMENT AND FINE AGGREGATE IN CONCRETE I Rohini 1(Department of Civil, Jeppiar SRR Engineering College, India) V.Arularasi 2(Depatment of civil,Jeppiar SRR engineering College,India) ABSTRACT: FLY ASH CONTAINS THE BASIC INGREDIENTS OF CEMENT

get price

BEHAVIOR OF CONCRETE ON REPLACEMENT OF SAND

2020-10-15  Sahu et al investigated the use of crusher dust only as a partial replacement of fine aggregates, and not as complete replacement, while Jaffar et al investigated the performance of high strength concrete with silica stone dust was a partial replacement of cement. Further, comprehensive tests on beam models are not reported so far.

get price

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4  Two grades of concrete M20 and M25 having nominal mix proportion of 1:1.5:3 and 1:1:2 respectively were used by weight and w/c ratio was fixed according to the slump requirement of 60mm. For this concrete mix, quarry dust was added for replacement of sand from 0% to 100% in step of 10%.

get price

(PDF) " Use of Quarry Dust as fine aggregates by Partial ...

The aggregate gives 1. Replacement of fine aggregate by quarry dust at partial volume, stability, resistance to wear or erosion, and other replace results the increase in strength of concrete. desired physical properties to the finished product. 2.

get price

Suitability of Quarry Dust as a Partial Replacement of ...

To overcome this problem, present study is focused on the suitability to utilize the quarry dust in Self Compacting Concrete (SCC) partially as fine aggregate with the natural fine aggregates. In this work, quarry dust is used as replacement of sand in a different level (0%, 15%, 30%, 45% and 60%) for producing the SCC.

get price

Effect of Marble Powder and Quarry Dust as Partial ...

2019-11-22  Effect of Marble Powder and Quarry Dust as Partial Replacement for Fine Aggregate on Concrete - written by Dr. M. Kannan, Sandhya, Swarnalakshmi published on 2019/11/22 download full article with reference data and citations

get price

Partial Replacement of Sand with Quarry Dust in Concrete

This present work is an attempt to use Quarry Dust as partial replacement for Sand in concrete. Attempts have been made to study the properties of concrete and to investigate some properties of Quarry Dust the suitability of those properties to enable them to be used as partial replacement materials for sand in concrete.

get price

PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

2019-4-21  concrete cubes of size 150mm×150mm×150mm were cast for finding its compressive strength. From the experimental studies it is observed that by 25% of partial replacement of cement with quarry dust improved hardened concrete properties. Keywords: Quarry dust, cement, water, aggregates. -----***-----1. INTRODUCTION Quarry dust is a waste product ...

get price

Partial Replacement of Fine Aggregates with Quarry Dust ...

2018-6-15  Quarry dust and Marble powder are the most used among such materials to replace river sand, which can be used as alternative to fine aggregate in concrete. In the present investigation workability and strength of concrete was evaluated by replacement of natural sand by Quarry dust and marble powder in equal proportions of 0%, 10%, 20%,

get price

BEHAVIOR OF CONCRETE ON REPLACEMENT OF SAND

2020-10-15  Sahu et al investigated the use of crusher dust only as a partial replacement of fine aggregates, and not as complete replacement, while Jaffar et al investigated the performance of high strength concrete with silica stone dust was a partial replacement of cement. Further, comprehensive tests on beam models are not reported so far.

get price

STUDY OF PARTIAL REPLACEMENT OF FINE AGGREGATE

2018-3-15  1. The compressive strength of concrete is i use of quarry dust up to 10% replacement of sand. F rom 10% there is decrease in compressive strength 2. The split tensile strength concrete is increased by the use of quarry dust up to 0% replacement of fine aggrega te. From 10% there is a decrease in split tensile strength. 3.

get price

Use of Quarry Dust to Replace Sand in Concrete – An ...

2021-6-4  Two grades of concrete M20 and M25 having nominal mix proportion of 1:1.5:3 and 1:1:2 respectively were used by weight and w/c ratio was fixed according to the slump requirement of 60mm. For this concrete mix, quarry dust was added for replacement of sand from 0% to 100% in step of 10%.

get price

Use of Crushed Granite Fine as Replacement to River Sand ...

2013-8-11  In India the use of quarry dust to replace river sand was reported by [2]. The use of rock dust as an alternative to natural sand was also reported by [5]. The use of up to 20% quarry waste fine as a partial replacement for natural sand in the production of concrete, in Malaysia was also reported [6].

get price